Rheological Characteristics of Wheat Dough Containing Powdered Hazelnuts or Walnuts Oil Cakes.

This study assessed edible oil industry byproducts, oil cakes (OC) based on hazelnuts and walnuts (HOC, WOC), to replace wheat flour dough (WD) based on farinograph and extensograph parameters and rheological measurements. The research hypothesis of this work is that replacing part of wheat flour with ground nut oil cakes modifies the rheological characteristics of the dough. WF was replaced at the level of 5%, 10% and 15%. It was shown that use of OC in flour mixtures at various levels significantly influenced the rheological properties of the dough. The water absorption of wheat flour and oil cake mixtures was higher than that of the control sample, and the average value of this indicator was 53.4%. The control sample had the lowest dough development time (DDT), and the presence of HOC or WOC in the system resulted in a significant increase in this parameter (p < 0.05). The average DDT of WDHOC cakes was 4.7 min and was lower compared to WDWOC which was 5.9 min. The WDWOC10% and WDWOC15% samples were characterized by the highest dough stability value and the lowest degree of softening (p < 0.05). The presence of OC in the flour mixtures increased the values of the storage and loss moduli, which was reflected in the K' and K″ values. The values of these parameters also increased as the level of OC addition increased. WDHOC doughs were characterized by higher values of the K' and K″ parameters compared to WDWOC. The results of the creep and recovery test showed that the dough with the addition of nut OC was less susceptible to deformation compared to the control dough (p < 0.05). The resistance to deformation increased with the increasing share of HOC or WOC in the mixtures. The average value of viscoelastic compliance (J1) of this parameter for WDHOC dough was on average 1.8 × 10-4 Pa-1, and for WDWOC 2.0 × 10-4 Pa-1. Nut oil cakes are an interesting technological addition to the dough. Their use may have a positive impact on the characteristics of the finished product and expand their application possibilities in the food industry. This is because the dough with the addition of nut cakes was more stiff and less flexible and susceptible to deformation.

Evaluation of flour protein for different bread wheat genotypes / Avaliação da proteína de farinha para diferentes genótipos de trigo de pão

Abstract Six different bread wheat genotypes; two Egyptian commercial varieties (control); Giza-168 and Gemmeiza-11, and four promising lines; L84 and L148, resulted via hybridization and M10 and M34 via radiation mutation program) were rheologically evaluated using extensograph and for protein, analysis using sodium dodecyl sulfate polyacrylamide gel electrophoresis (SDS-PAGE). The radiation mutant M10 and M34 had the highest maximum resistance which is a very good indicator of strong gluten. The amount of gluten content was higher in M10, L148, and M34 compared to the control samples Gz168 and Gm11. Sulfide amino acids (CYS and MET) are slightly higher in M10. The electrophoretic results and amino acid analyzers show that the best technological quality was exhibited by M10. Radiation mutants wheat genotypes have a protein with good characteristics, mainly gluten which is significantly higher compared to control samples. The rheological properties measured as extensograph and gel electrophoresis were much better in irradiated lines M10 and M34.

Resumo Seis diferentes genótipos de trigo de pão, duas variedades comerciais egípcias (controle) - Giza-168 e Gemmeiza-11 - e quatro linhas promissoras - L84 e L148, obtidas via hibridação, e M10 e M34, via programa de mutação por radiação - foram avaliados reologicamente por meio de extensógrafo, enquanto, para proteínas, foram feitas análises utilizando eletroforese em gel de poliacrilamida com dodecilsulfato de sódio (SDS-PAGE). Os mutantes de radiação M10 e M34 apresentaram a maior resistência máxima, o que é um indicador muito bom de glúten forte. A quantidade de glúten foi maior em M10, L148 e M34 em comparação com as amostras de controle Gz168 e Gm11. Os aminoácidos sulfurados (CYS e MET) são um pouco mais altos no M10. Os resultados eletroforéticos e analisadores de aminoácidos mostram que a melhor qualidade tecnológica foi exibida pelo M10. Os genótipos de trigo mutantes da radiação possuem uma proteína com boas características, principalmente o glúten, que é significativamente maior em comparação às amostras do grupo controle. As propriedades reológicas medidas, como extensógrafo e eletroforese em gel, foram muito melhores nas linhas irradiadas M10 e M34.